Document Type : Research Paper

Authors

Faculty of Materials and Metallurgical Engineering, Semnan University, Semnan, Iran.

10.22126/arww.2025.11292.1347

Abstract

Due to the increase in water pollution, especially heavy metals, many ways have been proposed to absorb and remove them. So far, various adsorbents have been used to remove pollutants. Semi-coke, a carbonaceous material, is susceptible to use as an adsorbent due to its unique properties, such as good specific surface area and porosity. Therefore, in this study, it was added to a solution containing lead ions after preparing semi-coke particles. The effect of various parameters such as pH, adsorbent dosage, and contact time on the ability of semi-coke to absorb lead ions was investigated. The results showed that semi-coke has a negative surface charge so that it can absorb small ions on its surface by an electrostatic attraction. The optimal pH values, adsorbent dosage, and contact time were obtained by investigating the results as 5, 2.0 g, and 60 min, respectively. Under optimal conditions, semi-coke could absorb 94 % of lead ions from the solution.

Keywords

Abas, S. N. A. et al. (2013) 'Adsorption process of heavy metals by low-cost adsorbent: A review', World Applied Sciences Journal, 28, pp. 1518-1530. doi: https://doi.org/10.5829/idosi.wasj.2013.28.11.1874
Ahmad, M. et al. (2015) 'Adsorption of heavy metal ions: role of chitosan and cellulose for water treatment', Langmuir, 79, pp. 109-155. doi: http://dx.doi.org/10.13040/IJPSR.0975-8232
Arora, R. (2019) 'Adsorption of heavy metals–a review', Materials Today: Proceedings, 18, pp. 4745-4750. doi: https://doi.org/10.1016/j.matpr.2019.07.462
Cheng, J. et al. (2023) 'Removal of heavy metal ions from aqueous solution using biotransformed lignite', Molecules, 28, pp. 5031. doi: https://doi.org/10.3390/molecules28135031
Ding, H. et al. (2022) 'Pyrolytic characteristics of Fushun oil shale and its by-products', Journal of Thermal Analysis and Calorimetry, 147, pp. 5255-5267. doi: https://doi.org/10.1007/s10973-021-10870-8
Dong, W. et al. (2019) 'A new route to fabricate high-efficient porous silicate adsorbents by simultaneous inorganic-organic functionalization of low-grade palygorskite clay for removal of Congo red', Microporous and Mesoporous Materials, 277, pp. 267-276. doi: https://doi.org/10.1016/j.micromeso.2018.11.013
Dowlatshahi, S., Haratinezhad Torbati, A. R. and Loloei, M. (2014) 'Adsorption of copper, lead and cadmium from aqueous solutions by activated carbon prepared from saffron leaves', Environmental Health Engineering and Management Journal, 1, pp. 37-44. Available at: http://ehemj.com/article-1-43-en.html (Accessed date: 16 February 2024).
Erto, A. et al. (2013) 'A comparison between a low-cost sorbent and an activated carbon for the adsorption of heavy metals from water', Water, Air, & Soil Pollution, 224, pp. 1-10. doi: https://doi.org/10.1007/s11270-013-1531-3
Etemadi, A., Koohestani, H. and Tajally, M. (2023) 'The effect of different carbon reductants on the production of ferrosilicon 75% on an industrial scale in an electric arc furnace', Heliyon, 9 (3), p. e13956. doi: https://doi.org/10.1016/j.heliyon.2023.e13956
Falsafi, M. H., Moghaddas, M. and Moghaddas, J. (2020) 'Removal of heavy metals from synthetic wastewater using silica aerogel- activated carbon composite by adsorption method', Journal of Applied Research in Water and Wastewater, 7, pp. 90-96. doi: https://doi.org/10.22126/arww.2020.3512.1093
Gao, X., et al. (2017) 'Effective adsorption of phenolic compound from aqueous solutions on activated semi coke', Journal of Physics and Chemistry of Solids, 102, pp. 142-150. doi: https://doi.org/10.1016/j.jpcs.2016.11.023
Guo, F., et al. (2013) 'Syngas production by carbon dioxide reforming of methane over different semi-cokes', Journal of Power Sources, 231, pp. 82-90. doi: https://doi.org/10.1016/j.jpowsour.2013.01.003
Huawei, Z., et al. (2014) 'Characteristics and stability of mercury vapor adsorption over two kinds of modified semicoke', The Scientific World Journal, 2014, p. 260141. doi: https://doi.org/10.1155/2014/260141
Hussain, A., Madan, S. and Madan, R. (2021) 'Removal of heavy metals from wastewater by adsorption', in Nazal, M. (ed.) Heavy Metals - Their Environmental Impacts and Mitigation. London: IntechOpen, pp.169-192.
Ince, M., and Ince, O. K. (2017) 'An overview of adsorption technique for heavy metal removal from water/wastewater: a critical review', International Journal of Pure and Applied Sciences, 3, pp. 10-19. doi: https://doi.org/10.29132/ijpas.358199
Koohestani, H. (2019) 'Photocatalytic removal of cyanide and Cr(IV) from wastewater in the presence of each other by using TiO2/UV', Micro & Nano Letters, 14, pp. 45-50. doi: https://doi.org/10.1049/mnl.2018.5170
Koohestani, H. and Hasanpoor, J. (2023) 'Using semi-coke as a reducing agent in the production of ferroalloys', International Journal of Iron & Steel Society of Iran, 20, pp. 1-9. doi: https://doi.org/10.22034/ijissi.2023.2002314.1264
Koohestani, H. et al. (2019) 'Investigation of photocatalytic performance of natural zeolite/TiO2 composites', Micro & Nano Letters, 14, pp. 669-673. doi: https://doi.org/10.1049/mnl.2018.5170
Kumar, M., Chung, J. S. and Hur, S. H. (2019) 'Graphene Composites for Lead Ions Removal from Aqueous Solutions', Applied Sciences, 9, p. 2925. doi: https://doi.org/10.3390/app9142925
Li, X. et al. (2024) 'Recent advances in environmental applications of Semi-coke: Energy storage, adsorption and catalysis', Journal of Environmental Chemical Engineering, 12, p. 112430. doi: https://doi.org/10.1016/j.jece.2024.112430
Lin, S.-H. and Juang, R.-S. (2002) 'Heavy metal removal from water by sorption using surfactant-modified montmorillonite', Journal of Hazardous Materials, 92, pp. 315-326. doi: https://doi.org/10.1016/S0304-3894(02)00026-2
Lv, Q. Q. et al. (2021) 'A comprehensive investigation of the reaction behaviorial features of coke with different CRIs in the simulated cohesive zone of a blast furnace', Plos one, 16, p. e0245124. doi: https://doi.org/10.1371/journal.pone.0245124
Ma, L. et al. (2022) 'Investigation of pyrolysis and mild oxidation characteristics of tar-rich coal via thermogravimetric experiments', ACS Omega, 7, pp. 25613-25624. doi: https://doi.org/10.1021/acsomega.2c02786
Mao, Y. et al. (2020) 'A 2-fold interpenetrated nitrogen-rich metal–organic framework for rapid and selective adsorption of congo red', Inorganic Chemistry, 59, pp. 8213-8219. doi: https://doi.org/10.1021/acs.inorgchem.0c00567
Nowrouzi, M. et al. (2017) 'An enhanced counter-current approach towards activated carbon from waste tissue with zero liquid discharge', Chemical Engineering Journal, 326, pp. 934-944. doi: https://doi.org/10.1016/j.cej.2017.05.141
Salmani, S., Rezaei, H. and Abyar, H. (2023) 'Adsorption potential of biochar derived from cotton waste for efficient removal of methylene blue from aqueous solutions', Journal of Applied Research in Water and Wastewater, 10, pp. 188-196. doi: https://doi.org/10.22126/arww.2024.10144.1319
Silva, R. R. D. et al. (2022) 'Interaction of Lead and Calcium with Biochar Produced from Cassava Waste: Perspectives for Agricultural and Environmental Application', Journal of the Brazilian Chemical Society, 33, pp. 1402-1413. doi: https://doi.org/10.21577/0103-5053.20220076
Tran, C. V., et al. (2020) 'Effective removal of Pb(II) from aqueous media by a new design of Cu-Mg binary ferrite', Acs Omega, 5, pp. 7298-7306. doi: https://doi.org/10.1021/acsomega.9b04126
Uzun, I. and Güzel, F. (2000) 'Adsorption of some heavy metal ions from aqueous solution by activated carbon and comparison of percent adsorption results of activated carbon with those of some other adsorbents', Turkish Journal of Chemistry, 24, pp. 291-298. Available at: https://journals.tubitak.gov.tr/chem/vol24/iss3/11/ (Accessed date: 18 February 2024).
Varadwaj, G. B. B., et al. (2017) 'Facile synthesis of three-dimensional Mg–Al layered double hydroxide/partially reduced graphene oxide nanocomposites for the effective removal of Pb2+ from aqueous solution', ACS Applied Materials & Interfaces, 9, pp. 17290-17305. doi: https://doi.org/10.1021/acsami.6b16528
Velarde, L. et al. (2023) 'Adsorption of heavy metals on natural zeolites: A review', Chemosphere, 328, p. 138508. doi: https://doi.org/10.1016/j.chemosphere.2023.138508
Wang, H. et al. (2023) 'Research on the performance of modified blue coke in adsorbing hexavalent chromium', Scientific Reports, 13, p. 7223. doi: https://doi.org/10.1038/s41598-023-34381-8
Wang, X. et al. (2020) 'Adsorption of heavy metal ions using semi-coke derived from pyrolysis of coal', Desalination and Water Treatment, 207, pp. 221-32. doi: https://doi.org/10.5004/dwt.2020.26377
Wang, Y. et al. (2021) 'From the waste semicoke to superabsorbent composite: Synthesis, characterization and performance evaluation', Journal of Polymers and the Environment, 29, pp. 4017-4026. doi: https://doi.org/10.1007/s10924-021-02171-w
Xu, D., et al. (2008) 'Adsorption of Pb(II) from aqueous solution to MX-80 bentonite: effect of pH, ionic strength, foreign ions and temperature', Applied Clay Science, 41, pp. 37-46. doi: https://doi.org/10.1016/j.clay.2007.09.004
Xu, L. and Wang, J. (2017) 'The application of graphene-based materials for the removal of heavy metals and radionuclides from water and wastewater', Critical Reviews in Environmental Science and Technology, 47, pp. 1042-1105. doi: https://doi.org/10.1080/10643389.2017.1342514
Yang, W. et al. (2015) 'Solvothermal fabrication of activated semi-coke supported TiO2-rGO nanocomposite photocatalysts and application for NO removal under visible light', Applied Surface Science, 353, pp. 307-316. doi: https://doi.org/10.1016/j.apsusc.2015.04.140
Yang, X. et al. (2011) 'Effect of pH, ionic strength and temperature on sorption of Pb(II) on NKF-6 zeolite studied by batch technique', Chemical Engineering Journal, 168, pp. 86-93. doi: https://doi.org/10.1016/j.cej.2010.12.039
Yao, Y. et al. (2022) 'Study on the slurrying properties of semi-coke with dispersants and the interaction between semi-coke particles based on E-DLVO theory', Applied Surface Science, 604, p. 154609. doi: https://doi.org/10.1016/j.apsusc.2022.154609
Zaimee, M. Z. A., Sarjadi, M. S. and Rahman, M. L. (2021) 'Heavy metals removal from water by efficient adsorbents', Water, 13, p. 2659. doi: https://doi.org/10.3390/w13192659
Zarei, M. et al. (2022) 'Removal of lead and cadmium with an optimized composite of expanded graphite/g-C3N4/phenylenediamine', Journal of Applied Research in Water and Wastewater, 9, pp. 154-166. doi: https://doi.org/10.22126/arww.2023.8253.1269
Zhang, L. et al. Modification of semi-coke powder and its adsorption mechanisms for Cr(VI) and methylene blue.  IOP Conference Series: Earth and Environmental Science, 2018. IOP Publishing, 022024.
Zhang, L., Zeng, Y. and Cheng, Z. (2016) 'Removal of heavy metal ions using chitosan and modified chitosan: A review', Journal of Molecular Liquids, 214, pp. 175-191. doi: https://doi.org/10.1016/j.molliq.2015.12.013
Zhang, Y. et al. (2023) 'Study on structural properties of semi-coke from pulverize coal pyrolysis and influencing factors during its thermal transportation process', Journal of Analytical and Applied Pyrolysis, 173, pp. 106052. doi: https://doi.org/10.1016/j.jaap.2023.106052
Zhao, F., et al. (2022) 'Preparation of efficient adsorbent with dual adsorption function based on semi-coke: Adsorption properties and mechanisms', Journal of Colloid and Interface Science, 626, pp. 674-686. doi: https://doi.org/10.1016/j.apsusc.2022.154609